Alfa Romeo 33 owners manual page 33

text version of content this owner's manual page from owners manual to the vehicle Alfa Romeo 33, year of production 1983 - 1995:

ENGINE MAIN MECHANICAL UNIT During engine removal from car, it is 6. With reference to the figure on after draining. necessary to remove engine and page 01-3 disconnect the following 9. Depending on what is to be gearbox - differential as single electric cables, preferably as indi- done, drain the oil from the oil sump unit. cated : - by removing the plug@ and, if . Put the vehicle on the auto lift and earth cable @I, from the necessary, drain the oil from the engage first gear. engine rear cover gearbox by removing . the drain high voltage cable @, from the plug 0. Screw the plugs again after . coil draining. Great care is required when dealinglow voltage and tachometer ~~tY~~~~~ngine~ j cables @ from coil . alternator and warning light 1. Operating from passenger com- supply cable@, from the alternator partment inside withdraw knob of l water temperature thermal con- gearbox lever, then remove the two lever bellows. tact cable @, from the thermal contact on the right hand head 2. Remove the hood (refer to: Group 56 - Hoods). . electric fan supply cable0 , from the fan 3. Working from inside the engine compartment, disconnect the battery . windshield and rear window earth cab le. washers pump cables @ from the pump 4. Disassemble the air filter as follo\lvs: l starter motor supplyI@ and energization @ cables from (1) Disconnect the corrugated air the starter motor intake pipes from the air filter by taking off the fixing clamps. . oil pressure switch cable@ , 1 Gearbox oil drain plug from manual contact on the rear 2 Engine oil drain plug (2) Disconnect the blow-by pipes. 3 Right head coolant drain plug cover Then remove the filter (Refer to: 4 Left head coolant drain Plug . electric fan thermal contact Group 04 Air Filter- Removal). accelerator and cable @, from the thermal 5. Disconnect 10. Lower the vehicle and with starter controls as follows: contact on radiator reference to figure of page 01-4, . (1) Extract the retaining ring0, fog lamp supply cables @, disconnect the following pipes and from fog lamp connectors slip the return spring@ off its couplings, preferably as indicated: l clamps and take off the slottedhead lamp supply cables0, from the headlamps hot water to heater delivery adjuster @ from the throttle pipe @, from the supply mani- control lever. . horn supply cables@I , from fold the horns (2) Release accelerator cable to- water from heater return gether with bracket @ unscrewing . water temperature transmitter rom the transmitter pipe @, from the waterpump cable @ , f the two securing screws located on intake intake manifold. on the intake manifold delivery pipe @ to block from l electronic ignition inductor (3) Disconnect hose and sheath of the water pump intake cable from distributor starter control of operating on sheath a water delivery coupling@, to . remove ignition distributor securing screw@ and on starter radiator control lever screw0. cap 2 together with spark plug 0 radiator water return coupl- cables ing 0, from the water pump . oil level sensor cable, from level intake rod (for models fitted with check control, only) fuel inlet line 0, from supply pump CAUTION: clutch oil delivery hose0, from pipe union (properly plug Unfix the electrical cables from their clamps, separate them from the drive the hose) servobrake vacuum intake unit so as not to impede its removal. pipe 0, from the suction mani- fold. 7. Unscrew and remove the coolant expansion tank plug. 11. Loosen bolt 0 securing engine 8. Raise the car and from beneath central support @ to body. remove the right hand drain plug 3 1 Bracket 4 Spring and then the left hand drain plug4 2 screw 5 Retaining ring 8 3 Screw 6 Adjuster under the cylinder block and drain off the coolant; screw the plugs again May 1983 01-6

owners manual Alfa Romeo 33

owners manual Alfa Romeo 33 - year of production: 1983, 1984, 1985, 1986, 1987, 1988, 1989, 1990, 1991, 1992, 1993, 1994, 1995 - Alfa Romeo 33 owners manual EN