Alfa Romeo 33 owners manual page 24

text version of content this owner's manual page from owners manual to the vehicle Alfa Romeo 33, year of production 1983 - 1995:

COMPLETE CAR 6. Fit oil filler cap back and start Refill radiator through relevant filler the engine letting it idle for about 2 according to following instructions: minutes. 7. Now check following items for 1. Refill the system till max. level any oil leaks: filter, pan, seal rings, mark in expansion reservoir is oil pressure transmitter, gaskets of reached. cylinder block andcylider head 2. Start the engine and warm it up covers, and cylinder head gaskets. If to normal running temperature thus necessary, tighten or replace items allowing the thermostat to open and that are not oil tight. 1 Coolant drain plugs to expel any air that was left over in 8. Turn the engine off and wait athe system. few minutes. 3. When engine is cold, top up 9. Take out dipstick and clean it; cooling system till max. level mark in 3. Fill cooling system with recom- fit dipstick back, take it out again expansion reservoir is reached. mended anti-incrustator following and check oil level making sure it 4. Fit filler cap back and.tighten it. relevant instructions for use. reaches the MAX reference mark. Recommended anti-incrustator: NALCO 1006 Checking the system’ INTERPROIND Jal Auto Stand. No. 3681-69955 1. Check coolant level in radiator making sure it is within MAX and 4. Remove again drain plugs fromMIN level marks. 2. Check hoses and unions for leaks cylinder block bottom and let making sure they are not in any way anti-incrutiator drain completely. damaged. 5. Thoroughly flush the system with running water. 3. Check filler cap making sure relevant spring, gasket and valves are 6. Fit drain plugs back to cylinder block and fill the radiator. in good working condition. 4. Test the electric fan as follows: (1) Disconnect thermostat wires and System refill short-circuit them. (2) Turn ignition key and check if electric fan-starts up. After having drained the cooling 5. Check radiator as per instruc- system, refill it with the kind and CAUTION: tions contained in Group 07 - Radia- quantity of coolant as shown in When checking oil level, park the car tor. the following chart. on a level surFace. 6. If top-up requires an abnormally large amount of coolant, check entire Sunimertime cooling system for leaks and elimi- nate them. COOLING SYSTEM Drinkable water I 7.3 (Imp Gal) (1.61) System flushing Radiator cap pressure test This operation should be performed 1. Fit union@ onto tester and Minimum out-C - IO only if plain water is used as engine -20 then insert it on expansion reservoir coolant in summertime. side temperature(S (14)(- 4) cap. Concentrated anti- 2. Apply pressure to the cap and freeze Std. No. check tester to make sure that when 1.8 3.65 368 I-69956 2.6 Ispecified pressure reading is reached, (Imp Gal) (0.40 (0.57) (0.80) 1. While engine is cold, remove ‘the relief valve opens up. radiator filler cap. Diluting drinkable 2. Loosenand remove drainwater 5.5 4.7 3.65 (Imp Gal! Il.211 (I .03)(0.80) plugs 0, located on bottom of Ready-to-use anti- Radiator filler cap relief pressure: cylinder block, let coolant drain completely and then fit plugs backfreeze Std. No. 68.6 kPa (0.69 bar; 3681-69958 7.3 I 0.7 kg/cm’; 9.96 p.s;i.l on cylinder block bottom and(1.61) (Imp Gal1 tighten them. 00-27 May 1983

owners manual Alfa Romeo 33

owners manual Alfa Romeo 33 - year of production: 1983, 1984, 1985, 1986, 1987, 1988, 1989, 1990, 1991, 1992, 1993, 1994, 1995 - Alfa Romeo 33 owners manual EN