owners manual Alfa Romeo 33

owners manual Alfa Romeo 33 - year of production: 1983, 1984, 1985, 1986, 1987, 1988, 1989, 1990, 1991, 1992, 1993, 1994, 1995 - Alfa Romeo 33 owners manual EN

Document: pdf (12.9 MB) 378 pages

all ratings: 0 average rating: 5

text version of content this owner's manual page from owners manual to the vehicle Alfa Romeo 33, year of production 1983 - 1995:

ENGINE COOLING SYSTEM CHECKS AND INSTALLATION pulley. For the timing and belt INSPECTIONS keying procedure refer to: Group 00 - Engine Maintenance. 3. Refit front cover of camshaft 1. Fit water pump with new The water pump cannot be over- belt, pulley, alternator, pump and relevant gasket to block and tighten hauled and in case of failure must: be alternator driving belt, in reverse replaced. securing screws to specified torque value. order of removal. 1. Check pump body and impeller 4. Stretch pump-alternator driving for indications of wide oxidation and belt. : Tightening torque corrosion; if any, replace pump. For the stretching procedure of belt 2. Verify that there is no excessive Screws securing water pump refer to: -Group 00 - Engine Mainte- play in the rotation and axial move- 19+24 N-m nance. ment of impeller. (1.9 + 2.4 kg-m 13.74 + 17.35 ft.lb) 5. At end of pump installation, pour the coolant and letting the engine run for a few minutes check 2. Check correct timing of engine and key camshaft belt on camshaft against coolant leakages. THERMOSTAT REMOVAL CHECKS AND INSPECTlOONS 1. Drain coolant up to the lower level of thermostat housing. 2. Detach coupling @ connecting thermostat cover to radiator. Thermostat should be checked in accordance with the following pro- 3. Screw out screws@ and remove cover cedure: 3 with relevant 0 1. Fit thermostat@ to suitable gasket @ _ test equipment. 4. Withdraw thermostat@ from Imousing @ . 2. Fill container with water and switch on equipment to heat water. 3. Check that, when thermostat opens, temperature value read on thermometer @ dial indicator is 84 + 88°C (183.2 + 190.4”F). 4. Additionally check that thermo- stat is fully open at98°C (208.4”F) and valve travel greater than 7 mm (0.28 in). 1 Thermometer If above values are not met, thermo- 2 Thermostat stat must be replaced. 1 Coupling 5 Washer 2 Clamp 6 Thermostat 3 Cover 7 Gasket 4 Screw 8 Housing May 1983 07-4

Download PDF

Click here to download a pdf file with an instruction manual for Alfa Romeo 33
year of production from: 1983

Do you prefer pdf format?
Find out how to download

Enter the code to download PDF file:

All pages in one PDF file!

How to get the code?
It's very simple! Just pay through a secure PayPal payment.
It will take no longer than a few minutes.
You will receive the code immediately after payment.
The code will be displayed on the screen and will be sent to you by e-mail address.